2003 Ford Taurus/ Sable How To Remove and Install Camshaft Synchronizer

download Removal 1. CAUTION: The No. 1 cylinder must be set on top dead center (TDC) of the compression stroke or the synchronizer assembly will not be installed correctly. CAUTION: Do not turn the crankshaft or the camshaft during the removal and installation procedure or the fuel system timing will be out of time with …

Continue reading ‘2003 Ford Taurus/ Sable How To Remove and Install Camshaft Synchronizer’ »

2003 Ford Taurus/ Sable, Camshaft Position (CMP) Sensor — 3.0L (2V) Removal And Installation

download Removal and Installation 1. Disconnect the battery ground cable. For additional information, refer to Section 414-01. 2. Remove the accelerator cable snow shield. 3. Detach the spark plug wire retainer. 4. Detach the wiring harness from the intake manifold support. 5. NOTE: The upper intake manifold is removed for clarity. Release the fuel charging …

Continue reading ‘2003 Ford Taurus/ Sable, Camshaft Position (CMP) Sensor — 3.0L (2V) Removal And Installation’ »

2001 Ford Windstar Camshaft Synchronizer Removal Installation

download REMOVAL 1. Rotate the crankshaft until the No.1 cylinder is at TDC of the compression stroke. CAUTION: Do not turn the crankshaft or the camshaft during the removal and installation procedure or the fuel system timing will be out of time with the engine and possibly cause engine damage. 2. Remove the Camshaft Position …

Continue reading ‘2001 Ford Windstar Camshaft Synchronizer Removal Installation’ »

2000-2003 Ford Taurus 3.0L 2V Gas And Ffv – Buck/ Jerk And Miss During Drive Cycle Above 3000 Rpm – No Dtc

download DESCRIPTION BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM – NO DTC – 3.0L 2V GAS AND FFV ENGINE ISSUE Some 2000-2003 Taurus, Sable, Ranger vehicles equipped with a 3.0L 2-valve gas or FFV engine may exhibit a buck/jerk/miss during drive cycles above 3000 RPM with no diagnostic trouble codes (DTC’s). A possible …

Continue reading ‘2000-2003 Ford Taurus 3.0L 2V Gas And Ffv – Buck/ Jerk And Miss During Drive Cycle Above 3000 Rpm – No Dtc’ »

2003-2005 Ford Thunderbird Wrench Light On With Both Dtc P2106 And P2135

download Ford: lincoln: mercury: this article supersedes tsb 05-09-15 to update the issue and dealer coding. Issue: some vehicles built 11/29/2004 and prior may exhibit the wrench light on with both p2106 and p2135 diagnostic trouble codes (dtcs). Action: replace the throttle position sensor (tps) following the instruction sheet included in the tps service kit. …

Continue reading ‘2003-2005 Ford Thunderbird Wrench Light On With Both Dtc P2106 And P2135’ »